Product ID:WELDWOOD COVE BASE ADHESIVE(CARTRIDGE)
MSDS Date:07/31/1992
FSC:8040
NIIN:00N040166
MSDS Number: BRZJD

DAP INC

DAYTON, OH 45401-0277
US

Emergency Phone: 800-543-3840

Info Phone: 513-667-4461

Cage: 90300

DAP INC.

277 DAYTON, OH 45401-0277 US

Telephone: 513-253-7154/800-543-3840

Cage: 90300

LESS WATER EXEMPT SOLVENT

RTECS: 9999999VO

MINERAL SPIRITS. PEL/TLV AS STODDARD SOLVENT

CAS: 64742-88-7

Fraction By Weight: 1-3%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ETHYLENE GLYCOL

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 1-3%

OSHA PEL 50 PPM, C

ACGIH TLV: 50 PPM,VAPOR, C

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY IRRITATE EYES, SKIN, NOSE
AND RESPIRATORY TRACT. INGEST OF ETHYLENE GLYCOL CAN CAUSE GI
IRRITATION, NAUSEA, VOMITING, DIARRHEA, AND, IF CONSUMED IN
SUFFICIENT QTY, DEATH. CHRONIC: REPORTS H AVE ASSOC PERM BRAIN &
NERV SYS DAM W/PROLONGED & REPEATED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INGEST OF ETHYLENE GLYCOL IN EXCESS
MAY LEAD TO RESPIRATORY &/OR CARDIAC FAILURE, &/OR KIDNEY AND LIVER
DAMAGE.
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:EYE: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. CONTACT A PHYSICIAN IMMED. SKIN: WASH WITH SOAP AND WATER.
INHAL: REMOVE TO FRESH AIR. CONTACT PHYS IMMED. INGEST: DO NOT
INDUCE VOMIT. CONTACT PHYS/REGIONAL POISON CONTROL CENTER IMMED.

Flash Point:>200F,>93C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED SURFACES.
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:USE ABSORBENT MATERIAL OR SCRAPE UP DRIED
MATERIAL AND PLACE INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED WHEN
NOT IN USE. KEEP OUT OF REACH OF CHILDREN. KEEP CONTAINERS FROM
EXCESSIVE HEAT & FREEZING.
Other Precautions:STORE AWAY FROM CAUSTICS AND OXIDIZERS.

Respiratory Protection:NOT REQUIRED UNDER NORMAL USAGE AND WITH
ADEQUATE VENTILATION. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE SUFFICIENT MECH VENT (LOC/EXHAUST) TO MAINTAIN
EXPOS BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT(SUPP DATA)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VENT: IN LOW AREAS (BASEMENTS, SUMPS, ETC). CHECK ALL LOW AREAS BEFORE
ENTERING.

Boiling Pt:B.P. Text:212F,100C
Vapor Pres:17.5@68F
Vapor Density:>1
Spec Gravity:1.53(H*2O=1)
Evaporation Rate & Reference:<1(N-BUTYL ACETATE=1)
Appearance and Odor:SMOOTH BUFF COLORED PASTE WITH A MILD SOLVENT ODOR
Percent Volatiles by Volume:45-50

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E.
OXIDES OF CARBON, OXIDES OF NITROGEN.

Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
STANDARDS. LIQUIDS CANNOT BE DISPOSED OF IN A LANDFILL. DO NOT
REUSE EMPTY CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.